Comparative Analysis of Steam Condensation Consisting of Air Outside of Single Tubes and Tube Bundles with Different Tube Diameters and Inclination Angles
-
摘要: 为评估不同传热管结构参数下单管与管束外含空气蒸汽冷凝传热规律的差异,基于外径12~19 mm、倾角0°~90°的单管和3×3管束在压力0.2~1.6 MPa、空气质量份额12%~87%的参数范围内开展了试验研究。结果表明:不同压力范围内,管径和倾角对单管和管束的影响呈现不同的规律。在压力小于0.8 MPa时,管束冷凝传热受管径和倾角影响的规律与单管总体一致,两者的冷凝传热系数均随管径和倾角的减小而增大。在0.8~1.6 MPa时,管束冷凝传热受管径和倾角的影响与单管存在明显差异。结合不凝性气体影响蒸汽冷凝传热的机制对所呈现的一致性和差异性规律进行了分析。Abstract: In order to evaluate the difference of condensation heat transfer law between single tube and steam containing air outside the tube bundle under different heat transfer tube structural parameters, based on a single tube with an outer diameter of 12~19 mm, an inclination angle of 0°~90° and a 3 × 3 tube bundle, an experimental study was carried out in the range of pressure 0.2~1.6 MPa and air mass share 12%~87%. The results show that the influence of tube diameter and inclination angle on single tube and tube bundle shows different rules in different pressure ranges. When the pressure is less than 0.8 MPa, the condensation heat transfer of the tube bundle is affected by the tube diameter and inclination angle, which is the same as that of a single tube. The condensation heat transfer coefficients of both increase with the decrease of tube diameter and inclination angle. At 0.8~1.6 MPa, the condensation heat transfer of tube bundle is significantly different from that of single tube due to the influence of tube diameter and inclination angle. The law of consistency and difference is analyzed according to the mechanism of the effect of non-condensable gas on steam condensation heat transfer.
-
Key words:
- Single tube /
- Tube bundle /
- Tube diameter /
- Inclination angle /
- Steam condensation /
- Non-condensable gas
-
表 1 不同压力条件下相对不确定度
Table 1. Relative Uncertainty under Different Pressure Conditions
压力/MPa 最大不确定度 最小不确定度 平均不确定度 0.15 0.215 0.101 0.158 0.20 0.146 0.054 0.089 0.40 0.076 0.038 0.050 0.60 0.065 0.035 0.043 0.80 0.058 0.035 0.042 1.00 0.052 0.034 0.040 1.30 0.045 0.034 0.038 1.60 0.042 0.034 0.037 -
[1] 欧阳予. 国外核电技术发展趋势(上)[J]. 中国核工业,2006(1): 23-26. [2] BIAN H Z, SUN Z N, ZHANG N, et al. A new modified diffusion boundary layer steam condensation model in the presence of air under natural convection conditions[J]. International Journal of Thermal Sciences, 2019, 145: 105948. doi: 10.1016/j.ijthermalsci.2019.05.004 [3] 李军,李晓明,朱晨,等. 基于分离式热管换热器的非能动安全壳热量导出系统实验研究[J]. 原子能科学技术,2018, 52(3): 453-458. doi: 10.7538/yzk.2017.youxian.0262 [4] BIAN H Z, SUN Z N, ZHANG N, et al. A preliminary assessment on a two-phase steam condensation model in nuclear containment applications[J]. Annals of Nuclear Energy, 2018, 121: 615-625. doi: 10.1016/j.anucene.2018.08.012 [5] BIAN H Z, SUN Z N, DING M, et al. Local phenomena analysis of steam condensation in the presence of air[J]. Progress in Nuclear Energy, 2017, 101: 188-198. doi: 10.1016/j.pnucene.2017.08.002 [6] UCHIDA H, OYAMA A, TOGO Y. Evaluation of post-incident cooling systems of light water power reactors[R]. Tokyo: Tokyo University, 1964. [7] LIU H, TODREAS N E, DRISCOLL M J. An experimental investigation of a passive cooling unit for nuclear plant containment[J]. Nuclear Engineering and Design, 2000, 199(3): 243-255. doi: 10.1016/S0029-5493(00)00229-6 [8] DEHBI A A. Analytical and experimental investigation of the effects of non-condensable gases on steam condensation under turbulent natural convection conditions[D]. Cambridge: Massachusetts Institute of Technology, 1990. [9] FAN G M, TONG P, SUN Z N, et al. Development of a new empirical correlation for steam condensation rates in the presence of air outside vertical smooth tube[J]. Annals of Nuclear Energy, 2018, 113: 139-146. doi: 10.1016/j.anucene.2017.11.021 [10] SU J Q, SUN Z N, FAN G M, et al. Experimental study of the effect of non-condensable gases on steam condensation over a vertical tube external surface[J]. Nuclear Engineering and Design, 2013, 262: 201-208. doi: 10.1016/j.nucengdes.2013.05.002 [11] 边浩志,孙中宁,丁铭,等. 含空气蒸汽冷凝换热特性的数值模拟分析[J]. 哈尔滨工程大学学报,2019, 40(2): 426-432. [12] 全标,边浩志,丁铭,等. 管束效应对含空气蒸汽冷凝传热影响数值分析[J]. 核动力工程,2019, 40(5): 61-66. [13] 杨世铭, 陶文铨. 传热学[M]. 第三版. 北京: 高等教育出版社, 1998:133-134.